Garage Door Spring Replacement Elkhorn

Project Description

In need of garage door repair, a homeowner in Elkhorn, NE, called Titan Garage Doors NE for servicing. As they opened their garage door, it made a loud noise and immediately stopped moving. We advised the owner not to operate the door for safety reasons, as we suspected there may have been a torsion spring breakdown. We dispatched a technician and confirmed that one of the springs was damaged. We immediately started the garage door spring replacement, installing a new, stronger torsion spring with a 20,000-cycle for a longer lifespan. After some safety and performance tests, we completed the job in under an hour, and the garage door operated normally once more. The customer thanked us for our prompt and dependable garage door spring replacement service.

Your garage door's springs are responsible for the work involved in opening and closing the door. If they break, it can be inconvenient and frustrating, not to mention disruptive to your daily routine. So it is helpful to know how they work, how to fix them, and what can cause them to malfunction. That way, you can avoid the inconveniences of not being able to get your car out of the garage.

Types of Springs in Garage Doors

Extension Spring

Extension springs are situated along both sides of the garage door track. These springs help compress or expand the door using cables and pulleys when the door is either open or closed.

Torsion Spring

These springs use one or two tightly wrapped springs to provide the door with opening and closing tension. The springs have cable drums at both ends mounted on a steel shaft. The torsion spring is installed on the header wall above the garage door and typically features a three-pronged support system. This system has two end-bearing plates and a center support plate.

Different kinds of garage door springs help to lift and lower the door. They become tighter as the door is lowered and help to raise it when the tension is released. It is important to remember that springs are under the most tension when the door is closed. Although garage door springs are designed to last long, they will eventually break. It usually happens when the door is closed, but occasionally the spring will fail while the door is open. If this happens, the door could fall and seriously injure anyone nearby. For this reason, it is important never to stand underneath an open garage door.

Common Causes of Garage Door Spring Break

Wear and Tear

The most common cause of garage door spring failure is normal wear and tear. Most garage door springs are designed to last for about 10,000 cycles, where a cycle is defined as the door being opened and closed once. Even though this number may seem high, keep in mind that just taking the car in and out of the garage requires at least two daily cycles.

If you find yourself using your garage door as your primary entrance to your home, it might be time to consider upgrading to extended lifespan torsion springs. Torsion springs are designed for heavy use and can withstand up to 20,000 cycles – far more than the average garage door spring. This upgrade will make your life easier and save you money in the long run by preventing costly repairs.

Rust and Corrosion

The formation of rust can significantly reduce a spring's lifespan because rust increases the resistance the coils experience as they oscillate, causing them to weaken and fail more quickly. Spraying the spring with a silicone-based lubricant three to four times a year will help keep it in good condition and increase its lifespan.

Inadequate Maintenance

The garage door springs are subject to wear and tear and may eventually fail. However, you can prolong their lifespan by carrying out proper maintenance. The coil should be lubricated with a few sprays at least three times a year. You should also check the garage door balance every season. Most people experience problems with their springs in winter, so it is advisable to check them more frequently during that period.

Garage Door Repair Near Me

If your garage door breaks down, it can ruin your whole day. But do not worry; Titan Garage Doors NE is here to help. We offer quick and efficient garage door repair services, so we will be there in no time to get your door back up and running. Plus, we carry all the necessary parts on our service vehicles, so we can usually fix the problem right away. Our technicians have years of experience in garage door spring replacement, so you can trust that we know what we are doing. Call us today for free estimates, and let us take care of all your garage door needs.

Project Gallery

Recent Projects

Comments

Call Now ButtonCall Now